PVC Insulated & Sheathed Power Cables Standards: IEC60502, GB/T12706-2008 Application: It is suitable to be installed in duct, tray or direct burial, with rated voltage of U0/U (0.6/1KV) for transmitting electricity. Service Conditions: 1. Regular nominal cross-sectional areas: 1.5 mm2, 2.5 mm2, 4 mm2, 6 mm2, 10 mm2, 16 mm2, 25 mm2, 35 mm2, 50 mm2, 70 mm2, 95 mm2, 120 mm2, 150 mm2, 185 mm2, 240 mm2, 300 mm2, 400 mm2, 500 mm2, 630 mm2, 800 mm2, 1000 mm2, 1200 mm2 2. It is recommended that the installation instructions indicated by the Local Electric Code, or any equivalent, be followed, so that the safeguarding of persons and the integrity of the product will not be affected by eciencies in the installation.
This cables are used as power distribution and transmission at rated voltage of 0.6/1kV. Working temperature: max 70 degree centigrade Short circuit: 5 seconds at max 160 degree centigrade Models: VV: Copper Core, PVC insulated and Sheathed Electric Cable VLV: Aluminum Core, PVC insulated and Sheathed Electric Cable VV22: Copper Core, PVC insulated, Steel tape armoured, PVC Sheathed Electric Cable VLV22: Aluminum Core, PVC insulated, Steel tape armoured, PVC Sheathed Electric Cable VV32: Copper Core, PVC insulated, Fine steel wire armoured, PVC Sheathed Electric Cable VLV32: Copper Core, PVC insulated, Fine steel wire armoured, PVC Sheathed Electric Cable VV42: Copper Core, PVC insulated, Heavy steel wire armoured, PVC Sheathed Electric Cable VLV42: Aluminum Core, PVC insulated, Heavy steel wire armoured, PVC Sheathed Electric Cable ZR-VV: Copper Core, PVC insulated and Sheathed, Flame retardant Electric Cable ZR-VLV: Aluminum Core, PVC insulated and Sheathed, Flame retardant Electric Cable Installation: While installation, the temperature should not lower than 0 degrees Celsius, if the ambient temperature is lower than 0 degrees Celsius, the cable should be preheated. The bending radius should not be smaller than 8 times of diameter of cable. After installation, voltage withstand test for 15 minutes at 8.4kV direct current should be performed.
33kV XLPE Insulation DSTA PVC Sheath Power Cable
11KV 3c 240mm2 XLPE Insulation DSTA PVC Sheathed Power cable
Application:XLPE Cable is used indoor or outdoor, in tunnel, cable furrow or pipe, to be laid underground, be applicable to the well, water inside and fall in the bad soil. Standards:IEC60502-2, BS7870-4, BS7870-7, BS7870-8 Cores: 1 Core, 3 Core Conductor:Cu or Aluminum Insulation:XLPE (Cross-Linked Polyethylene) Armor:non-armor, steel tape armored, steel wire armored Sheath:PVC or PE Sheath Color:Black or Colors Product Description: - XLPE insulated PVC sheathed power cable (XLPE/PVC Cable) - XLPE insulated steel tape armored PVC sheathed power cable (XLPE/STA/PVC Cable) - XLPE insulated steel wire armored PVC sheathed power cable (XLPE/SWA/PVC Cable) - Flame retardant XLPE insulated PVC sheathed power cable (FR/XLPE/PVC Cable) - Flame retardant XLPE insulated steel tape armored PVC sheathed power cable (FR/XLPE/STA/PVC Cable) - Flame retardant XLPE insulated steel wire armored PVC sheathed power cable (FR/XLPE/SWA/PVC Cable) FR â?? Flame Retardant http://www.xlpecable.com
We offer Bharat Cab PVC Insulated Power Cable that are made as per IS: 1554 (Part I) up to 1.1 KV grade. The PVC Insulated Power Cable, we supply, is suitable for low-tension, fixed installation and are also used as control cables for process and manufacturing industries. The clients can avail the PVC Insulated Power Cable from us at the market leading price. Features : - Strong and made for easy handling. - Resistant to water, moisture, oils and chemicals. - PVC black compounds can resist ultraviolet degradation. - Specially formulated PVC is flame retardant and reduces emission of halogens and smoke. Suitable For : Continuous use between 30oC and 70oC and upto 85oC for Heat Resistant applications.
Standard:hd 21, din vde 0281, bs 6004, bs 6004 Voltage:600/1000v Capacity:50000 coils/week Applicable standards:bs 6004, iec 60227 Voltage rating:300/500v Temperature rating: 70â°c Core colours:single core: brown or blue Two core:brown and blue Three core:brown, black and grey sheath colour: grey This product is used as hanging cable, drawing cable and installation for field line, electric appliances and instruments, electronic equipment and automatic devices for electric power, chemical and so on.
Application :- The Power Cables are used under ground as well as over head transmission of power in power plants, industries, projects and all other electrical installations. Features :- Manufactured from bright annealed 99.97% pure bare copper & aluminum conductors. These cables are insulated with PVC compound. Taped/Extruded inner sheath. Round steel wire / flat galvanised steel grip armoured. The inner & outer sheaths can be PVC, HR PVC, FRLS, HR-FRLS or FR depending upon the application and requirement. Technical Data :- Working Voltage : Up to 1100 V Temperature Range : -15�°C to +70�°C or +85�°C in HR PVC Power Cable Sizes : 1.50 Sq. mm to 400.00 Sq. mm in 2, 3, 3 & 4 core. Copper Control Cable Sizes : 1.50 Sq. mm, 2.50 Sq. mm up to 24 cores. Color Codes : 2 Core Cables - Red, Black 3 Core Cables - Red, Yellow & Blue 3 Core Cables - Red, Yellow, Blue & Black (for Neutral) 4 Core Cables - Red, Yellow, Blue & Black 5 Core Cables - Red, Yellow, Blue, Black & Grey 6 Core Cables & above - Adjacent cores are blue for reference and yellow for direction in each lay Black outer sheath Specification : IS:1554 (Part-1) Packing : 500 / 1000 meters on drums
Application:XLPE Cable is used indoor or outdoor, in tunnel, cable furrow or pipe, to be laid underground, be applicable to the well, water inside and fall in the bad soil. Standards:IEC60502-2, BS7870-4, BS7870-7, BS7870-8 Cores: 1 Core, 3 Core Conductor:Cu or Aluminum Insulation:XLPE (Cross-Linked Polyethylene) Armor:non-armor, steel tape armored, steel wire armored Sheath:PVC or PE Sheath Color:Black or Colors Product Description: - XLPE insulated PVC sheathed power cable (XLPE/PVC Cable) - XLPE insulated steel tape armored PVC sheathed power cable (XLPE/STA/PVC Cable) - XLPE insulated steel wire armored PVC sheathed power cable (XLPE/SWA/PVC Cable) - Flame retardant XLPE insulated PVC sheathed power cable (FR/XLPE/PVC Cable) - Flame retardant XLPE insulated steel tape armored PVC sheathed power cable (FR/XLPE/STA/PVC Cable) - Flame retardant XLPE insulated steel wire armored PVC sheathed power cable (FR/XLPE/SWA/PVC Cable) FR â?? Flame Retardant http://www.xlpecable.com
As one of the leading Suppliers, we keep our quality in synchronization with our reputation and offer the best PVC Power Cables to the buyers. Only strict and different quality tests, we undertake, ensure the utmost quality of our products.
As one of the leading Suppliers, we keep our quality in synchronization with our reputation and offer the best PVC Power Cables to the buyers. Only strict and different quality tests, we undertake, ensure the utmost quality of our products.
Our FRLS - PVC Power / Control Cables are manufactured from the optimum quality raw materials to add maximum durability & unbeatable performance. Flame Retardance, Low Smoke Emission and Acid Gas Emission. Quality tested & approved by the competent authority.
We are ranked as a dominating Manufacturer, Supplier and Exporter of excellent LT PVC Power Control Cables. These are designed using modern technology and quality assured raw materials, which are procured from certified vendors of the arena in adherence with international parameters. Owing to their safety, high quality, prevention from accidental short circuit, zero supply interruptions, performance accuracy and protection against the worst conditions these LT PVC Power Control Cables provided by us are massively applauded and demanded among the masses. Features: Seamless performance Dependability Longer life Comprehensive prices.
PVC Insulated & Sheathed Cable Cu(or Al)/PVC/PVC Standard:IEC 60502-1/BS6346 Voltage:0.6/1kV Certificate:TUV SUD PSB, CCC Standard : It is manufacture under IEC 60502-1/BS6346, also can be made to order. Application: It is used to transmit and distribute power on the power line of A.C. rated voltage 0.6/1kV. Using features: 1. Rated voltage: Uo/U: 0.6/1kV 2. No. of core: Ranging from single core to 5 cores, inlcuding earth core. 3. The highest allowed operating temperature of conductor for long-term working is 70oC. In short-circuit (Max. long-term is no more than 5 seconds), the highest temperature for conductor is no more than 160oC. 4. D.C. resistance of the conductor complies with the stipulations of IEC 60502-1/BS6346. 5. The environment temperature should be no lower than 0oC when lay. Otherwise it should be preheated. 7. Working Frequency Voltage Test: 2.5Uo+2kV/5min without puncture.
Application :- The XLPE (Cross Link Poly Ethylene) Power Cables are used under ground as well as over head transmission of power in power plants, industries, projects and all other electrical installations. Features :- Manufactured from bright annealed 99.97% pure bare copper & aluminum conductors. These cables are insulated with XLPE compound. Taped/Extruded inner sheath. Round steel wire / flat galvanised steel grip armoured. The outer sheaths can be PVC, HR PVC, FRLS or FR depending upon the application and requirement. Technical Advantage of XLPE Insulation :- Higher current rating, higher short circuit rating (approx 1.2 times that of PVC), thermosetting in nature, higher insulation resistance (1000 times more than PVC cables), higher moisture resistance, better resistance to surge currents, low dielectric losses, better resistance to chemicals and corrosion, longer service life. Comparatively higher cable operating temperature 90�°C and short circuit temperature 250�°C. Technical Data :- Working Voltage : Up to 1100 V Temperature Range : -15�°C to +90�°C Power Cable Sizes : 1.50 Sq. mm to 400.00 Sq. mm in 2, 3, 3 Copper Control Cable Sizes : 1.50 Sq. mm, 2.50 Sq. mm up to 24 cores. Color Codes : 2 Core Cables - Red, Black 3 Core Cables - Red, Yellow & Blue 3 Core Cables - Red, Yellow, Blue & Black (for Neutral) 4 Core Cables - Red, Yellow, Blue & Black 5 Core Cables - Red, Yellow, Blue, Black & Grey 6 Core Cables & above - Adjacent cores are blue for reference and yellow for direction in each lay Black outer sheath Specification : IS:7098 (Part-1) Packing : 500 / 1000 meters on drums
Standard:iec 245-53, iec 245-66 Voltage:300/500v, 450/750v Capacity:2000km/month Highly flexible Durable service lifespan Resistant to uv-radiation, moisture, oil and fats Conductor:fine stranded copper wire Insulation:rubber compound Outer sheath:rubber compound These robust rubber sheathed cables can be used where high demands are placed flexibility and mechanical stress. For application on construction sites, in steel works and rolling mills in heating and air-conditioning systems, in the bottling industry, in machinery and plant construction, in the chemical industry and painting systems, as well as for the professional and the hobby enthusiast
Application:XLPE Cable is used indoor or outdoor, in tunnel, cable furrow or pipe, to be laid underground, be applicable to the well, water inside and fall in the bad soil. Standards:IEC60502-2, BS7870-4, BS7870-7, BS7870-8 Cores: 1 Core, 3 Core Conductor:Cu or Aluminum Insulation:XLPE (Cross-Linked Polyethylene) Armor:non-armor, steel tape armored, steel wire armored Sheath:PVC or PE Sheath Color:Black or Colors
Cable Standard IS 694:2010, BS 6500 Silent Features - High Flexibility - Excellent resistant to moisture, abrasion, grace, oil - Long Life - Excellent mechanical & electrical properties Technical Data Working Temp : Max.+70�°C Nominal Voltage : 1.1 KV Test Voltage : 3.0 KV Min. Bending Radius : 6 x Cable Diameter Standard Packing Coils 100, 200, 300 , 500, 1000m. Conductor Flexible Bare or Tinned Bunch Copper as per IS:8130-1984 Insulation PVC as per IS:5831-1984 Sheath PVC as per IS:5831-1984 Core Color As per IS 694 : 2010 2 Core â?? Red & Black 3 Core â?? Red, Black, Green or Red, Yellow and Blue 4 Core - Red, Yellow, Blue and Green or Black Application Ideal For industrial induction motor, power tools, electrical machinery etc.
Standard:iec Voltage:300/500v, 450/750v Capacity:2000km/month Multiple core applicable Extra flexible applicable Flat shape appliable Nominal sectional area:0.5-400mm2 1.Conductor Solid or class b or class c stranded copper 2.Insulation Pvc General purpose wiring for lighting and power - residential, commercial, industrial buildings in accordance with the national electrical code, maximum conductor temperature of 75â°c in wet or dry locations, for circuits not exceeding 600 volts
PVC Insulation and Sheath Control Cable
