Series NKVW Vacuum pump sets.
Introduction:
This filtration plant is special for filtering waste cooking oil; it removes impurity, odor, water, acid and alcohol etc. from oil completely and effectively. Treated cooking oil color is limpidity, oil is good smell. This filtration plant is suitable for food factory, cooking oil factory, vegetable oil factory, it can help factory reclaim remnants oil. Also, TPF is a good filtration part for bio-diesel oil making.
The machine feature and working process:
1. This plant composed by two parts, one is the press filter, and other one is the vacuum oil purifier system. The press filter can remove the big and tiny impurity; the precision of purification can reach to 1 Micro. The Vacuum system equips three grades filter (primary filter, mass water separator, and fine filer). All process works under the vacuum condition.
2. For the primary filter, which is made of the stainlessness steel, it is anti-rust and anti-corrupt, it mainly removes the residual impurity which escape from the press filter, making sure the oil have not any impurity when it goes into the water separator and vacuum separator.
3. The water separator, which equips the special filter, which mainly remove the mass water from the oil, because usually the waste cooking oil always contains much water, so we need remove the mass from the oil. After the water separator, the oil just contains the tiny water and soluble water.
4. After the process of the water separator, the oil will goes into the vacuum separator, which adopts three-dimensional duplex evaporation and film evaporation. For protecting the oil nature, it is better that the oil temperature is lower than 80 C, Because our machine works under the vacuum and low pressure condition, so it dont need heat the oil to 100 C, usually it just need heat the oil to 45 C, Then it can remove the tiny water, soluble water, acid, alcohol and other volatility liquid and so on completely and effectively.
5. The fine filer, which is equips the stainlessness steel filter, the purification hole is less then 1 Micro, which can make sure the oil is completely clear, no any impurity.
Table Parameters:
Parameters Unit TPF -10 TPF -30 TPF -50 TPF -100
Flow rate L/H 600 1800 3000 6000
Vacuum degree Mpa -0.06 ~- 0.095
Working pressure Mpa í_0.4
Working Temperature C 0~80
Clean Degree NAS 6 Grade
Impurity Size ª¦m 1
Gas Content % 0.1
Acid Value mKOH/g í_0.05
Water content PPM í_10
Working noise dB(A) í_75
Electric heating power KW 36 55 72 84
Total electric power KW 50 68 86 98
Inlet (outlet) caliber mm º¦25 º¦25 º¦32 º¦42
Size mm 1700x1050x1750 1800x1050x1800 1800x1150x1800 2000x1250x1950
Weight Kg 650 720 880 1000
Application:
Series JYWL horizontal-closed filtration device is completely closed type and stainless steel mesh filtering system, it is high efficiency, energy saving, closed operation, high-grade filtering precision and decolor, so it is widely applied in chemical, petroleum, food, pharmaceutical and other industries for treating unqualified turbine oil, engine oil, lube oil, also for the waste water. It can separate pigment, particles, wax, colloid, free carbon etc. effectively. Series JYWL adopts novel structure, the machine is mainly composed of seat system, mesh filtering system, seal system, discharging system. Manual operation, live Bolt locks seal. It realizes closed filtering operation, easy discharging residua, no environment pollution.
Features:
1.Completely closed filtering system, no environment pollution.
2.Automatic pull-out structure of filter plate, observe conveniently, easy clean.
3.Double-side filter, large filtering size, large capacity for holding residua.
4.Vibrating discharging system, reduce labor intensity.
5.This equipment also can be done as the big capacity and big size filtering system.
Parameters:
Index name Unit JYWL-5 JYWL-10 JYWL-15 JYWL20 JYWL-30
Flow rate m3/h 5 10 15 20 30
Lift m 5 8 8 10 15
Cleanness NAS 7 6 6 6 6
Weight KG 95 105 120 130 140
Application:
Series JL portable oil purifier mainly deal with unqualified insulating oil, turbine oil, lubricating oil etc., this machine can do precision filtering, it usually equips three-stage filters, also can equip four or five stage filters as per users requirements . Light weight, easy operation, it can be used as oiling machine for long distance and high-lift oiling works.
Technical parameters:
Index name Unit JL-32 JL-50 JL-80 JL-150 JL-200
Flow rate m3/h 1.9 3 6 9 12
Lift m 5 8 8 10 15
Cleanness NAS 7 6 6 6 6
Power KW 0.75 0.75 2.2 3 4
Power supplier 380V 50HZ 3Ph(As per users option)
Weight KG 95 105 120 130 140
