Modular Mobile Concrete Mixing Plant Suppliers and Manufacturers

APPLICATION OF SK-HB K-SILICATE MORTAR : * K-SILICATE is used for jointing Acid Resisting brick in construction of vessels in suited for construction of fume chambers and stacks handling hot, dry Acid fumes and vapors. It is also used for jointing chemical resisting stoneware pipes. K-SILICATE cement is good bedding material for Acid â?? Resisting bricks and tiles. The concrete surface needed protection should be dryed, clean and rough. The bricks or tiles will be set with K-SILICATE cement over concrete surface applied with a suitable an impermeable interliner. When Bedding and Jointing Materials are the same. On the treated surface bricks or tiles are bedded to a thickness of about 6 mm and tamp gently with a wooden piece till the paste squeezes out of joints. The paste that is squeezed out of the joint should be removed by trowel with good finishing. After the mortar of the joint is dryed treat the joints with 20% Hydrochloric Acid Solution by means of brush. A.R.lining should be always in contact with Acid and not with water. Concrete subtract like Floor, Wall, tanks and similar surface should be protected with a membrane of Bitrok Mastic or compound steel tanks should be protected with rubber or PVC subjected to chemical conditions and temperature of chemical media. The Brick lining is recommended over the protective layer of Bitrok Mastic. When Bedding and Jointing Materials are Different. Spread the silicate type mortar about 6 to 8 mm thick on the back of the tile or brick. Press the tile on the bed leaving required space for joints between tiles for bricks. After the bedding mortar is set, fill Mp the joints with specified cement.PRODUCT DATA SHEET FOR SK-HB ( K-SILICATE) MORTAR A general purpose cement for acid conditions Resistant to High & medium concentrations of most of the common organic and inorganic acids except Hydroflouric acid. Recommended where the concentration of the acid is high suitable for high temperature. Unsuited to aqueous solutions, alkaline conditions. PREPARATIONS OF MORTAR : * Measure 1 part by weight of K-SILICATE solution into a suitable mixing pan. * Add slowly and gradually 3 parts by weight K-SILICATE mortar and mix thoroughly to form a smooth mortar. * In hot season very large batches of mortar will become stiff quite rapidly therefore small batches, not exceeding 4 to 8 kgs. Will be prepared. * The cement mortar will be used before it starts setting.

Bitumen Primer * Bitumen Primer is Bituminous air curing ready mixed Acid & Alkali resistant special primer. Application * Concrete surface must be clean, dry and rough. No primer should be applied over smooth and wet surface. * After cleaning the concrete surface, one coat of Bitumen Primer should be applied with brush and allow to dry thoroughly. * The drying time will depend upon the temperature. * 24 Month at the temperature 30C (+2OC) Packing * Bitumen Primer: 25 Liter Drum Note * Bitumen Primer contains volatile and slightly toxic solvent. Keep away from spark and open flames at working area. * Bitumen premier it is manufactured using bitumen solution which is used for sealing of prime porous and non-porous surface, and also to protect residential and commercial building. * Bitumen Primer is used to protect substrate against corrosive attack, is suggested to apply anti-corrosive primer.It is best for protection against sub-striate against atmospheric corrosion and chemical corrosion. It is a mixed substance made up of organic liquids that are highly sticky, water proof, viscous,acid proof as with all surface coating, good Bitumen Premier is used for long life of the system. it is applied by brush or roller and allowed to dry before any water proofing treatment so to avoid solvent it is used in defects such as cracks, broken mortar joints, etc. are to be repaired prior to Bitumen primer application. Product Details: Grade Standard Technical Grade Physical State - Liquid Usage - Industrial Color - Black Characteristics: Appearance/Color - Pasty liquid/ black Chemical Base - Bituminous rubber emulsion. Density - 1.0 kg/l Curing Speed/ Rate - 3 - 4 hours Tack free after - 5 - 10 hours Cured after - 2 - 4 days (Dependent on ambient Solid Content by - temperature, substrate temperature, Weight - relative Water Content by weight - humidity and thickness of the coating) Bitumen Content - 41% by weight - Thixotropic (The viscosity can be adjusted by - Viscosity adding up to max. 5% of clean water. - Stir well prior use) - For light protection: 1.0 mm min. Coating - For greater protection: ~ 1.5 - 2.0 mm Thickness applied - in two coats. Water Penetration - 48 h, 1 bar: 78.5 cm2: 0 ml under Hydrostatic - 96 h, 4 bar: 78.5 cm2: 33 ml Pressure - Water vapor 6 x 10-7 mg / hmPa Permeability Service - -30 C to 200 C Temperature - Adhesion Concrete - Very good, Timber: Very good, Metal: Moderate Glass: Poor

SauMix is a Vegan, Gluten-Free, Plant-based and Non-GMO starch which makes Soups, Gravies and Sauces - Tastier, Smoother, Thicker and Yummy. SauMix has excellent Shear Stability and Water Holding Capacity. SauMix is 100% vegetarian and naturally made product which does not have any preservatives and Mono sodium Glutamate (MSG). APPLICATIONS TOMATO KETCHUP & OTHER SAUCE: Mix 3-5 % of SauMix in partial amount of water and completely mix without any lump formation. Then add it along with remaining water to the sauce, after adding all other raw materials. TOMATO SOUP: Mix 2 -3 % of SauMix in required amount of water and add at the last of cooking for Soups. For Instant Soup mixes, Add required percentage of SauMix along with all dry ingredients and mix well. PREMIXES (INSTANT SOUP MIX, KETCHUP MIX, AND SAUCE MIX): Mix 3-5 % of SauMix at the time of blending while adding other raw materials FEATURES AND BENEFITS ï?? Improves thickness of the sauce, soups and ketchups. ï?? Better dispersion of spices and other ingredients uniformly. ï?? Improves smooth texture of sauce, soups and ketchups. ï?? Enhance product's flavor. ï?? Stable high viscosity. ï?? Excellent shear stability. ï?? Excellent water holding capability. During the shelf life, it maintains the consistency and avoiding the water separation. ï?? 100% Natural and 100% vegetarian product. DOSAGE For excellent results, use 3 to 5% SauMix of total batch size.

CWS-MS is Maize based pregelatinized starch. It is Plant based, physically modified and Non GMO fine powder made from maize, which is moderately soluble in cold water and has a very good binding strength. CWS-MS is a Perfect additive for coating the nuts and snacks. CWS-MS also acts as Stabilizing agent in cream fillings, sauces, soup mixes, gravies, pasty creams and other food product industries.

CWS-TS is a Tapioca based pregelatinized starch. It is gluten free, grain free, Plant based and Non GMO fine powder made from Cassava root, which is soluble in cold water and has a very good binding strength. CWS-TS is a Perfect additive for coating the nuts and snacks. CWS-TS also acts as Stabilizing agent in cream fillings, sauces, soup mixes, gravies, pasty creams and other food product industries.

CWS-PS is a clean label starch cold water soluble potato starch. It is gluten free, grain free, Plant based and Non GMO fine powder made from Cassava root, which is soluble in cold water and has a very good binding strength. CWS-TS is a Perfect additive for coating the nuts and snacks. CWS-TS also acts as Stabilizing agent in cream fillings, sauces, soup mixes, gravies, pasty creams and other food product industries.

CWS-MS is Maize based pregelatinized starch. It is Plant based, physically modified and Non GMO fine powder made from maize, which is moderately soluble in cold water and has a very good binding strength. CWS-MS is a Perfect additive for coating the nuts and snacks. CWS-MS also acts as Stabilizing agent in cream fillings, sauces, soup mixes, gravies, pasty creams and other food product industries.

CWS-TS is a Tapioca based pregelatinized starch. It is gluten free, grain free, Plant based and Non GMO fine powder made from Cassava root, which is soluble in cold water and has a very good binding strength. CWS-TS is a Perfect additive for coating the nuts and snacks. CWS-TS also acts as Stabilizing agent in cream fillings, sauces, soup mixes, gravies, pasty creams and other food product industries.

We make every batch of super greens immunity booster healthy soups with the freshest and purest sources of greens we can find. That means real, natural ingredients from mother earth - no lab stuff. So if you notice a slight difference in color or labeling, don't worry. The flavor is fresh and honest, like spring in our home country India. Just add 1 spoon of herbal powder to lukewarm water and stir well or Can be mixed with dosa batter or to any curry like sambhar. Soup instant mix with no added color nor preservatives gives rich and thick natural soupy consistency. Spinach or Keerai is a healthy soup & one of the most nutrient-dense plants on the planet, it contains every essential amino acid making it a complete plant protein. Greens and herbs are a rich source of antioxidants, and anti-inflammatory properties and have anti-anxiety and anti-stress. This powder is a highly essential nutrient that increases the natural defenses of the body. Improves cell structure and immunity. It has strong cognitive & stress-relieving properties. effects that may help in improving brain functions & strengthen memory. Herbal powder soups make you stronger & active and increase endurance & stamina. It is a raw green superfood with energy boosters, multivitamins, antioxidants, healthy nutrition, and metabolism. Mix herbs give healthy bones and joints, nourished eyes, brain, and skin.

LAS 5NF is a Lactose Substitute Non- Fat Solid is an Enzymatically Modified, Clean Label, Vegan, Gluten-Free, Plant-based and Non-GMO starch used as curdling and thickening agent in Flavored milk,Ice cream,Gelato,Cottage cheese, Vegan Cheese,Sour cream,Whipped cream and Vegan butter. It is 100% naturally made which does not have any preservatives and Mono sodium Glutamate (MSG). APPLICATIONS 1. First add 4% to 10% of LAS 5NF based on the Protein Content of the Milk in cold (4�°C to 36�°C) condition. Dissolve it well without Lump formation. 2. Mix 10% of extra water to total mix and heat the milk mixer to 85�°c & hold for 12 min with continuous stir .The product is settle down when stir is not good. 3. Cool the pasteurized milk to 43�°c to 45�°c with slow stir and then add required quantity of culture and stir it slowly for even mixing of culture. 4. Then keep it in an incubator @ 43�°C for 6 hours and transfer it to chiller. DOSAGE For excellent results, use 4 to 10% of LAS 5NF of total batch size, based on the protein content of the milk. For lower protein content in the milk higher LAS 5NF need to be used.

This is chemical setting Furan based chemical resistant mortar which is combination of Liquid and Powder, when mixed in proper proportion from workable mortar which after setting and curing give of liquid and give black highly cross linked composites. Furan When set and cured is resistant to highly corrosive acids, alkalis and to powerful organic solvents such as ketones, Aromatic and Chlorinated solvents. It has extreme resistant to Acidic & alkalis, Salts, Greases and Detergents. It resists to Organic & Inorganic acids at their boiling temperature. It is suitable against mild chlorine Gas (dry) phosphorous trichloride, pyridine at room temperature. Furan is especially useful where resistance to mixed media such as aqueous acids /alkalis and organic solvents is needed in chemical plant process and waste streams. Carbon filled Furan is used against corrosive effect of hydrofluoric acid & its salts. PREPARATION OF FURANE MORTAR : Mortar consist of Furan solution and Furan powder. The average mixing ratio necessary to obtain mortar with good working consistency is 1 part by weight Solution & 3 part by weight powder. The ratio will vary slightly depending on temperature and working conditions.Stir the liquid thoroughly before using. Place liquid in a suitable shallow mixing pan. Add powder by weight in the solution mix thoroughly and rapidly until all lumps are dispersed and the mortar is completely homogenous. Spread out the mortar in a thin layer, not more than ¾ thick, to dissipate the heat of reaction and lengthen the working life. Batch size can be varied depending upon the temperature and the speed with which the masons are working. Very large batches will become stiff quite rapidly. Make sure that all the Furan Motrar is used from the pan before another batch is mixed.When working at temperature above 40 C, very small batches not more than 2 Kgs, should be prepared. When working at temperature below 15C the liquid should be kept warm.

Just add 1 spoon of herbal powder to lukewarm water and stir well or Can be mixed with dosa batter or to any curry like sambhar. Soup instant mix with no added color nor preservatives gives rich and thick natural soupy consistency. Spinach or Keerai is a healthy soup & one of the most nutrient-dense plants on the planet, it contains every essential amino acid making it a complete plant protein. Greens and herbs are a rich source of antioxidants, and anti-inflammatory properties and have anti-anxiety and anti-stress. Brahmi powder for memory provides highly essential nutrients and increases the natural defenses of the body. Improves cell structure and immunity. It has strong cognitive & stress-relieving properties. effects that may help in improving brain functions & strengthen memory. Herbal powder soups make you stronger & active and increase endurance & stamina. It is a raw green superfood with energy boosters, multivitamins, antioxidants, healthy nutrition, and metabolism. Mix herbs give healthy bones and joints, nourished eyes, brain, and skin. We make every batch of super greens immunity booster healthy soups with the freshest and purest sources of greens we can find. That means real, natural ingredients from mother earth - no lab stuff. So if you notice a slight difference in color or labelling, don't worry. The flavor is fresh and honest, like spring in our home country India.

CURIA YG is a Vegan, Gluten-Free, Plant-based and Non-GMO starch used as curdling and thickening agent in Yogurt and Lassi. No addition of preservative and Mono sodium Glutamate in the starch. APPLICATIONS 1. First add 2% to 10% of CURIA- YG based on the Protein Content of the Milk in cold (40C to 360C) condition. Dissolve it well without Lump formation. 2. Heat the milk mixer to 850 c & hold it for 12 minutes with continuous stirring. 3. Cool the pasteurized milk to 43 0c to 45 0c with slow stirring and then add required quantity of Culture and stir it slowly for even mixing of culture. 4. Then keep it in an incubator @ 430c for 6 hours and transfer it to chiller. OR 1. Add 2% to 10% of CURIA- YG based on the Protein Content of the hot milk at 800C to 850C and stir continuously for 2 minutes without lump formation 2. Cool the milk to 43 0c to 45 0c with slow stirring and then add required quantity of Culture and stir it slowly for even mixing of culture. 3. Then keep it in an incubator @ 430c for 6 hours and transfer it to chiller. DOSAGE For excellent results, use 2 to 10% CURIA-YG of total batch size, based on the Protein Content of the Milk. For Lower Protein Content in the Milk higher Curia-YG NEED TO BE USED.

ChikMat P1 is a Vegan, Gluten-Free, Plant-based and Non-GMO starch. ChikMat P1 is used as an excellent additive or ingredient for Crispy oil fried vegetarian and non-vegetarian products. ChikMat P1 will provide structure, tenderness & binding power in baking. It even gives excellent crispiness by better even coating and with low oil absorption. It is 100% naturally made which does not have any preservatives and Mono sodium Glutamate (MSG). APPLICATION: GLUTEN FREE ALTERNATIVE FOR FLOUR AND BAKERY: ChikMat P1 can make a suitable gluten-free alternative for flour in baking recipes like Waffles, Muffins, Gluten free flour mixes. ChikMat P1 attract and hold more water and helps to increase the moisture content in baked goods and provides structure, tenderness & binding power in baking. FRYING FOODS: ChikMat P1 could serve as a suitable fried food coating where the coating is light and crisp. It helps to lock the flavour of the product while frying. It can improve the texture of the coat foods, such as chicken, fish, or vegetables, before frying and reduces the absorption of oil. The product such as oil fried Nuggets, Potato Shots, and Cheese bites. Even it can be used in Premixes- 65 Masala, Instant Crispy Fry Mix, Manchurian Mix, Bonda Mix, etc... ChikMat P1 coating can give the foods a golden and crispy outer layer during the frying process. PROCEDURE: Replace 5-20 % of Corn flour with ChikMat P1 then add at the time of blending while adding other raw materials FEATURES AND BENEFITS Increase special appearance to the fried products. Better dispersion of spices and other ingredients. Improves texture. Enhance flavor. Low oil absorption. Excellent crispiness. Better even coating

ChikMat P1 is a Vegan, Gluten-Free, Plant-based and Non-GMO starch. ChikMat P1 is used as an excellent additive or ingredient for Crispy oil fried vegetarian and non-vegetarian products. ChikMat P1 will provide structure, tenderness & binding power in baking. It even gives excellent crispiness by better even coating and with low oil absorption. It is 100% naturally made which does not have any preservatives and Mono sodium Glutamate (MSG). APPLICATION: GLUTEN FREE ALTERNATIVE FOR FLOUR AND BAKERY: ChikMat P1 can make a suitable gluten-free alternative for flour in baking recipes like Waffles, Muffins, Gluten free flour mixes. ChikMat P1 attract and hold more water and helps to increase the moisture content in baked goods and provides structure, tenderness & binding power in baking. FRYING FOODS: ChikMat P1 could serve as a suitable fried food coating where the coating is light and crisp. It helps to lock the flavour of the product while frying. It can improve the texture of the coat foods, such as chicken, fish, or vegetables, before frying and reduces the absorption of oil. The product such as oil fried Nuggets, Potato Shots, and Cheese bites. Even it can be used in Premixes- 65 Masala, Instant Crispy Fry Mix, Manchurian Mix, Bonda Mix, etc... ChikMat P1 coating can give the foods a golden and crispy outer layer during the frying process. PROCEDURE: Replace 5-20 % of Corn flour with ChikMat P1 then add at the time of blending while adding other raw materials FEATURES AND BENEFITS Increase special appearance to the fried products. Better dispersion of spices and other ingredients. Improves texture. Enhance flavor. Low oil absorption. Excellent crispiness. Better even coating

Moringa powder organic provides highly essential nutrients and increases the natural defenses of the body. Improves cell structure and immunity. Reduces blood sugar levels. Promotes digestion and bowel movement. Moringa leaf powder organic also gives stronger bones. Herbal powder soups make you stronger & active and increase endurance & stamina. It is a raw green superfood with energy boosters, multivitamins, antioxidants, healthy nutrition, and metabolism. Mix herbs give healthy bones and joints, nourished eyes, brain, and skin. We make every batch of super greens immunity booster healthy soups with the freshest and purest sources of greens we can find. That means real, natural ingredients from mother earth - no lab stuff. So if you notice a slight difference in color or labeling, don't worry. The flavor is fresh and honest, like spring in our home country India. Just add 1 spoon of herbal powder to lukewarm water and stir well or Can be mixed with dosa batter or to any curry like sambhar. Organic moringa powder with no added color nor preservatives gives rich and thick natural soupy consistency. Spinach or Keerai is a healthy soup & one of the most nutrient-dense plants on the planet, it contains every essential amino acid making it a complete plant protein. Greens and herbs have a better source of Bioavailable Minerals & Vitamin like A, B, B1, C (Ascorbic Acid), K & Trace Minerals

Organic soup provides highly essential nutrients and increases the natural defenses of the body. Improves cell structure and immunity. Promotes a healthy circulatory system. Promotes digestion and bowel movement. Mudakathan keerai powder also beautifies the skin Herbal powder soups make you stronger & active and increase endurance & stamina. It is a raw green superfood with energy boosters, multivitamins, antioxidants, healthy nutrition, and metabolism. Mix herbs give healthy bones and joints, nourished eyes, brain, and skin. We make every batch of super greens immunity booster healthy soups with the freshest and purest sources of greens we can find. That means real, natural ingredients from mother earth - no lab stuff. So if you notice a slight difference in color or labeling, don't worry. The flavor is fresh and honest, like spring in our home country India. Just add 1 spoon of herbal powder to lukewarm water and stir well or Can be mixed with dosa batter or to any curry like sambhar. Organic soup with no added color nor preservatives gives rich and thick natural soupy consistency. Spinach or Keerai is a healthy soup & one of the most nutrient-dense plants on the planet, it contains every essential amino acid making it a complete plant protein. Greens and herbs have a better source of Bioavailable Minerals & vitamins like A, B, B1, B2, B3, B6, C (Ascorbic Acid), E & Trace Minerals.

EXTRUPLUS P1 (POTATO BASED) is a Physically modified, Clean-Label, Gluten free, Plant based, Vegan and Non GMO starch. EXTRUPLUS P1 (POTATO BASED) is used as a perfect additive for Extruded & Oil Fried Snacks, Papad , Pasta and Noodles etc. EXTRUPLUS P1 (POTATO BASED) has no preservative and no Mono sodium Glutamate. FEATURES AND BENEFITS: ï?· Helps to reduce cooking time. ï?· Reducing oil consumption. ï?· Improves Crispiness ï?· Improves Expansion & Volume ï?· Improves texture. ï?· Enhance product's flavor. ï?· 100% Natural and 100% vegetarian product APPLICATION: *EXTRUPLUS P1(POTATO BASED) can be used in all type of extruded products like corn puffs, veggie straw snacks, pork rinds, cheese snacks (puffs and curls), Tortilla/Tostada Chips. *EXTRUPLUS P1(POTATO BASED) is also suitable for Bajji Bonda Mix. *EXTRUPLUS P1(POTATO BASED) can be applied for Pasta and Noodles. *Replace 2-5 % of rice flour with EXTRUPLUS P1(POTATO BASED) and add at the time of blending, after adding all raw materials. DOSAGE For excellent results, use 2-5% EXTRUPLUS P1(POTATO BASED) of total batch size.