Single side butyl rubber wrap tape anti corrosion for gas pipe Outer Wrapping Tape The XUNDAT200 series is Cold applied tape coating system for corrosion protection of Oil, Gas, Petrochemical, and Waste Water underground or overhead pipelines. The outerlayer tape backing shall be compounded so that it will be resistance to outdoor weathering.The outer-layer tape shall be applied after the inner-layer tape by hand or with a wrapping machineCorrosion protection tape for metal pipeline is polyethylene cold applied tape coating system for corrosion protection of Oil, Gas, Petrochemical, and Waste Water underground or overhead pipelines. Usage and Features: 1. Widely used on underground and overhead pipelines anticorrosion protection system. 2. Excellent adhesion to pipe and self 3. Resistant to UV 4. Can be applied over a wide temperature range from-30°C to 80°C 5. Good conformability and consistent uniform thickness 6. Cold applied ,and easily applied with no special equipment 7. Compatible with common pipe coatings 8. Excellent resistance to cathodic disbonding 9. Meets ASTM D 1000 Standard 10. Long term corrosion protection and mechanical resistance The tape consists of two layers, adhesive and film Inner layer: butyl rubber Outer layer: polyethylene Thickness: 0.35 - 1.30mm Width: 50-300mm Length: 30 - 200m Application 1 Rust Removal Steel Surface needs treating. Its quality shall reach Sa2 or St3 grade as prescribed in GB8923-88 Pre-paint Steel Surface Rust Grade and Rust-removal Grade, and it shall be dust-free.2 PrimingPrimer shall be stirred well before painting. An even film of primer is painted on the steel surface that is rust-removed completely and dust-free. After the primer dries up (one may feel no sticky). The steel pipe can be wrapping with tape (it usually takes 3 to 5 minutes). The primer dosage usually amounts to 80 to 100g / m². 3 Inner Tape (Anti corrosion Tape) & Outer Tape (Protection Tape) Wrapping The steel pipe that is painted with primer is wrapping with tape by means of suitable devices or tools as per joint needs, and wraps the inner tape and then wraps the outer tape. Tape tensibility can be 10 to 20 N / cm. The overlapped length between beginning and end of an adhesive tape shall be no less than 1/4 circumference of the steel pipe and the total length of adhesive tape shall be no less than 100mm. each film shall be paralleled, and must not be twisted and rumpled.
Self adhesive bitumen waterproof tape aluminum foil tape 1 description: Aluminum foil tape, flashing tape, peel/stick roof tape, shelf adhesive bitumen tape, waterproof tape, sealing tape has a heavy aluminum facing or pe together with extra thick rubberized asphalt based adhesive system. Roof waterproof tape is recommended for most types of roofs, windows and flashing problems including: Trailers Rv's Mobile homes Industrial buildings Roof awnings Truck trailers Chimney flashing Roof to wall flashing Ridge flashing Window frames of glass, metal, plastic Wood including osb Clay and cement roof tiles 2. Structure The specification of the tape consists of three layers. Film backing: aluminum foil or polyethylene Adhesive: polymer modified asphalt and butyl rubber Interleaf: antiadhesive film treated with silicone 3. Features: Aluminum backing is more moldable - it conforms better to irregular surface features - for weather-tight seals Excellent for flashing No messy sealant Stays flexible Aggressive grip Superior adhesion Assure immediate leakproof results Easy, fast application No harmful voc’s Ideal adhesive/sealant thickness
Xunda anti corrosive tape for underground pipe wrap tape Xunda tape is mainly engaged in five series of products, which are inner tape, outer tape, joint tape, tape primer, and putty codd categories in nearly 100 specifications. They can be used for the purposes of steel pipe surface corrosion resistance for various pipelines in facility projects of petroleum, petrochemical industry, city gas, oil and gas storage and transportation, power, water supply, metallurgy, civil aviation, etc. 1.1 inner tape: (anticorrosion tape, anti corrosion tape, anticorrosive tape) is for anticorrosion of underground, underwater, & overhead pipelines. 1.2 outer tape: (protection tape, protective tape) is for protection of pipe and the surface of inner tape from damages. 1.3 joint tape: (polyethylene tape, polyethylene tapes, pe tape, rubber tape, butyl tape, butyl rubber tape) is for anticorrosion of field joints, fittings, & specifically piping. Component: backing: polyethylene pe & adhesive: butyl rubber Thickness: 0.38mm to 1.27mm, Width: 50mm to 300mm Length: 30 to 300m 1.4 tape primer: (synthetic primer) complementary product covers of the rusting steel pipe and enable to enhance the adhesive to the pipe since it is working with the adhesive of the polyethylene tape. P19: solid content 19%; P27: solid content 27%.
We are manufacturer of wide range of wrap roll, lldpe stretch film, colored stretch film with export quality with use of sabic, lotrane, exxon mobile, aramco raw materials. We are manufacture 15 cm to 100 cm ( 150 mm, 200 mm, 250 mm, 300 mm, 450 mm, 500 mm, 1000 mm )
12mic metallized PET films 2.2 OD
The foil is mainly applied to the pretreated metal surface,vacuumed and heated in large oven for 3-5 minutes,the pattern of transfer foil will be transferred to metal surface as a surface of decoration. Widely used on the flat or shaped surface of aluminum, metal plates, metal windows and doors and other metal materials. The advantage of our foil: 1.Colorful wood grain,and looks real. 2.Good resistance to UV,can be used indoor&outdoor. 3.Wide woodgrain designs to be chosen from 4.Customized designs are accepted. 5.Wide width for selection. worthwhile sea or air shipment
1)High transparent 2)100% Virgin Raw Material 3) Excellent stretch properties 4)pre-stretch rate 150-500% 5)Thickness:12Mic-30Mic 6)Width:5Cm-180Cm 7) Lenght:100M-7000M
Packing BOPP/OPP film Adhesive Acrylic based Thickness 38~65mic Width Common is12mm,24mm,36mm,45mm,48mm,50mm,55mm,60mm,72mm Length 20m-1000m For various sealing and wrapping and heavy boxes sealing and strapping
Jining XunDa Anticorrosion tape for pipeline 100 Series is polyethylene cold applied tape coating system for corrosion protection of Oil, Gas, Petrochemical, and Waste Water underground or overhead pipelines. Usage and Features:1. Widely used on underground and overhead pipelines anticorrosion protection system. 2. Excellent adhesion to pipe and self 3. Resistant to UV 4. Can be applied over a wide temperature range from-30¡ãC to 80¡ãC 5. Good conformability and consistent uniform thickness 6. Cold applied ,and easily applied with no special equipment 7. Compatible with common pipe coatings 8. Excellent resistance to cathodic disbonding 9. Meets ASTM D 1000 Standard 10. Long term corrosion protection and mechanical resistance The tape consists of two layers, adhensive and filmInner layer: butyl rubberOuter layer: polyethyleneThickness: 0.35 - 1.30mmWidth: 50-300mmLength: 30 - 200mTapes specifications: 1) T-150 with 0.51mm / 20mil thickness and 50 - 300mm width2) T-165 with 0.65mm / 25mil thickness and 50 - 300mm width3) T-180 with 0.80mm / 30mil thickness and 50 - 300mm width packing in carton
Pipeline Wrap tape The tape as consists of two parts: 1. Adhesive: Inner layer of Butyl rubber. 2. Backing: Outer layer of Polyethylene(PE) Plastic. Specification of tape: Inner wrap tape: T-140 (0.38mm), T-150 (0.51mm), T-165 (0.64mm), T-180 (0.76mm), T-1100 (1.02mm), T-1130 (1.27mm); Outer wrap tape: T-240 (0.38mm), T-250 (0.51mm), T-265 (0.64mm), T-280 (0.76mm), T-2100 (1.02mm), T-2130 (1.27mm); Joint wrap tape: T-365 (0.64mm), T-380 (0.76mm), T-3100 (1.02mm), T-3130 (1.27mm); Thickness:0.38mm-1.3mm, Width:50mm, 75mm, 100mm, 150mm, 230mm, 300mm Lengh: 30-300m Synthetic Primer: P19: Solid content 19%; P27: Solid content 27%. Mastic filler:: N99: Solid content 99 packing in carton
Polyethylene Pipelines Cold Applied Tape Composition: It is tape-shaped anticorrosion material made of Polyethylene film heat laminated with adhesive layer of butyl glue. Usage: It is extensively used in the pipework of oil and natural gas transportation, petrochemical industry, electric power, metallurgy, urban natural gas network of pipes, the outside anticorrosion project of the metal pipes involved as well as the outside anticorrosion project of the underground and overhead metallic conduit of the works of petrochemical industry, natural gas and coal transportation Thickness: 0.30 - 1.30mm Width: 50, 75, 100, 150, 230, 300mm Length: 30 - 200m Features: Excellent adhesion to pipe and self Resistant to UV Can be applied over a wide temperature range Good conformability and consistent uniform thickness Easily applied with no special equipment Compatible with common pipe coatings Excellent resistance to cathodic disbonding Meets ASTM D 1000 Standard Cold applied Application: Prepare surfaces by removing all loose scale, rust or other foreign matter by grit blasting or wire brush. Surface must be clean, dry and free of grease. Apply thin film of Butyl Primer to all surfaces to be wrapped and allow to dry. Peel back interleaving and apply adhesive side of the tape to the surface and press down. Apply the tape spirally with enough tension to make it conform. Remove interleaving as wrapping proceeds. Overlap each turn by at least 1" or 55% to achieve double thickness. Irregular surfaces such as valves, flanges, etc. packing in carton
Pipe Wrap, Joint Coatings & Accessory Products Xunda carries a full line of products to complement the main line coating systems and meet the challenges of modern pipeline activities. Utility work: hand-applied tape products for gas utility, oil field, and plumbing applications on small diameter pipe. Coating repair: cold-applied tape products for plant and field repair of main line coating systems. Specialty fittings and fabrication work: a variety of tape systems and mastics that conform to irregularly-shaped pipe. Field joints: single-sided and double-sided tape systems that conform to bell and spigot, welded and mechanically-coupled field joints. ROW construction: Rockshield system, tie-in, and above-ground tape systems for use at the job site by the pipeline contractor. Offshore Tapes: Whether replacing PVC on welded joints or protecting Pier Pilings, Xunda has the tape coating for the job. packing in carton
Specifications : 45 cm x 8 m , OEM orders are welcomed. 60 cm x 50 m , 90 cm x 100 m , 105 cm x 120 m , 120 cm x 200 m. Carton As Your Request.
WASHI TAPE with unique design of holographic laser paper tape. It's washi paper tape with the same application of fashion, shinny, and outstanding of holographic laser paper tape. It's perfect for craft works and scrapbooking. Perfect match for giftwrapping, card making, and decoration. Polybag, Pillow Pag, Paper Box
Features 1.Gloss & Clarity:Benkai wraps excellent gloss and clarity increases the cleanness of the product. 2.Freshness:Benkai wraps high transmission rate of O2 and CO2 and excellent moisture retention keep the food stay fresh. 3.Anti-fog:Benkai wrap can break up the water drops automatically to maintain its good clarity as well as the foods freshness. 4.Cold Resistance:Benkai wraps excellent cold resistance remains the softness even under freezing. 5.Wrapping Applicability:Due to its adequate softness, stickiness and elongation, Benkai wrap can be well stretched over the food tightly without the trouble of sticking up and bad wrapping. 6.BPA Free More Product Details MaterialPVC Type: Cling film Usage: Food Wrapping & Preservation Hardness: Soft Processing Type: Casting TransparencyHigh Transparent Width: 250mmX600mm Length: 300mX3000 Meters Thickness: 9-20 Micron Place of Origin: Taiwan Temperature resistance-60162;J Packaging: 6, 2 or 1 roll/ctn OEM Printing on core and cartons Available Main Application PVC Cling Film is widely used for the food wrapping and preservation purpose, we supply large specifications which are used by food industries, supermarkets, catering companies, hotels and families. Company Introduction Company ProfileX Benkai is a leading supplier of PVC Cling Film in Taiwan. We can do the customized specifications which cover from the Industrial level to the Household products. By years of experience cooperating with importers, catering companies, supermarkets and distributors over the world, Benkai is not only a supplier, but also a reliable partner of customers. Thanks & Regards Email : sales7(at)benkaico.com Web : www(dot)benkaico(dot)com Tel:886-4-24518789 Fax:886-4-24517828 6 rolls / 2 rolls / 1 rolls per carton depends on the roll size
Min.Order Quantity: 10 Ton/Tons Price: US$ 2~3/Kilogram Payment Terms: Irrevocable L/C , T/T Packaging & Delivery Packaging Details: 6 rolls / 2 rolls / 1 rolls per carton depends on the roll size Delivery Detail: 45~60 days Features 1.Gloss & Clarity:Benkai wraps excellent gloss and clarity increases the cleanness of the product. 2.Freshness:Benkai wraps high transmission rate of O2 and CO2 and excellent moisture retention keep the food stay fresh. 3.Anti-fog:Benkai wrap can break up the water drops automatically to maintain its good clarity as well as the food;s freshness. 4.Cold Resistance:Benkai wrap;s excellent cold resistance remains the softness even under freezing. 5.Wrapping Applicability:Due to its adequate softness, stickiness and elongation, Benkai wrap can be well stretched over the food tightly without the trouble of sticking up and bad wrapping. 6.BPA Free More Product Details Material:PVC Type: Cling film Usage: Food Wrapping & Preservation Hardness: Soft Processing Type: Casting Transparency:High Transparent Width: 250mm X600mm Length: 300m X3000 Meters Thickness: 9-20 Micron Place of Origin: Taiwan Temperature resistance:;J-120;J Packaging: 6, 2 or 1 roll/ctn OEM Printing on core and cartons Available Main Application PVC Cling Film is widely used for the food wrapping and preservation purpose, we supply large specifications which are used by food industries, supermarkets, catering companies, hotels and families. Company Introduction Company Profile¡X Benkai is a leading supplier of PVC Cling Film in Taiwan. We can do the customized specifications which cover from the Industrial level to the Household products. By years of experience cooperating with importers, catering companies, supermarkets and distributors over the world, Benkai is not only a supplier, but also a reliable partner of customers. Thanks & Regards Email : sales7(at)benkaico.com Web : www(dot)benkaico(dot)com Tel:886-4-24518789 Fax:886-4-24517828 6 rolls / 2 rolls / 1 rolls per carton depends on the roll size
Min.Order Quantity: 5 Ton/Tons Price: US$ 2-3/Kilogram Payment Terms: Irrevocable L/C , T/T Packaging & Delivery Packaging Details:Good Paper Carton Delivery Detail:45-60 days Features 1.Gloss & Clarity:Benkai wrap;s excellent gloss and clarity increases the cleanness of the product. 2.Freshness:Benkai wrap;s high transmission rate of O2 and CO2 and excellent moisture retention keep the food stay fresh. 3.Anti-fog:Benkai wrap can break up the water drops automatically to maintain its good clarity as well as the food;s freshness. 4.Cold Resistance:Benkai wrap;s excellent cold resistance remains the softness even under freezing. 5.Wrapping Applicability:Due to its adequate softness, stickiness and elongation, Benkai wrap can be well stretched over the food tightly without the trouble of sticking up and bad wrapping. 6.BPA Free More Product Details Material:PVC Type: Cling film Usage: Food Wrapping & Preservation Hardness: Soft Processing Type: Casting Transparency:High Transparent Width: 250mm;X600mm Length: 300m;X3000 Meters Thickness: 9-20 Micron Place of Origin: Taiwan Temperature resistance:-60;J Packaging: 6, 2 or 1 roll/ctn OEM Printing on core and cartonsAvailable Main Application PVC Cling Film is widely used for the food wrapping and preservation purpose, we supply large specifications which are used by food industries, supermarkets, catering companies, hotels and families. Company Introduction Company Profile;X Benkai is a leading supplier of PVC Cling Film in Taiwan. We can do the customized specifications which cover from the Industrial level to the Household products. By years of experience cooperating with importers, catering companies, supermarkets and distributors over the world, Benkai is not only a supplier, but also a reliable partner of customers. Thanks & Regards Email : sales7(at)benkaico.com Web : www(dot)benkaico(dot)com Tel:886-4-24518789 Fax:886-4-24517828 Good Paper Carton
-Thickness: 0.32mm/Laminated smart glass film--0.38mm/self-adhesive smart film -Operation mode:On/off, Dimming, remote control. -Width: 1.2meters, 1.4meters, 1.5meters, 1.8meter(1.8m width only only with non-adhesive smart film) -Roll Length: 30-100meters. -Dimension: customized. -Color: White, Grey, Black, Green, Blue, Pink, Yellow. -UV Block:98%+1- -Operating Temperature:-20 -Storage temperature: -40 -Visible angle:150° -Rated Voltage: 48-60VAC -Power consumption: less than 5watt/square meter. -Switch speed:
This product is an unique composite material that glass fabric is inside and ptfe is coated on both side. Reinforced by glass fabric inside and ptfe coated on outsde, outstading mechanical strength and heat resistance , non-adhesiveness , slipping property and chemical resistance due to ptfe property. Thickness 40um ~ 300um Width: ~1500mm Various application fields such as, electronic industries, packaging, releasing sheet and food ~1500mw * 100m or 50m
This product is an unique composite material that glass fabric is inside and ptfe is coated on both side. Reinforced by glass fabric inside and ptfe coated on outsde, outstading mechanical strength and heat resistance , non-adhesiveness , slipping property and chemical resistance due to ptfe property. Thickness 40um ~ 300um Width: ~1500mm Various application fields such as, electronic industries, packaging, releasing sheet and food ~1500mw * 100m or 50m
